2018 Annual Camper Maintenance

Anthony Galluscio Camper Maintenance

Becca and I are going on a combined work-vacation to New York. My son, Bobby, came home to help me do the required maintenance on our 2015 Jayco Jay Flight 23RB Travel Trailer. We basically followed the list that we created last year. It is my hope that we can help other camper owners finding themselves in a similar situation, and even add to this list next year based on comments and feedback received.

Here are some stats on our camper:

  • Years Owned: 3 years
  • Total Mileage: 8629 miles
  • Total Nights Camping: 112 Nights Camping

For the record, here is a list of all of the systems on which we performed preventative maintenance:

System Tasks Notes


Configured backup assist N/A. In my opinion this is a complete waste.
Removed Gear Rust Used wire brush and Rustoleum rust reformer
Lubricated ball and sway connectors Used standard grease.


 Inspect  Hoses, connectors, and tanks in good repair
 Clean  Wiped down tanks, hoses, and fittings
 Refill  Took one tank to ACE Hardware and had it “topped off” for $14. Switched the backup tank to primary.


 Inspect  Noticed some rust starting.


 Inspect Seams  Notices small holes and cracks starting in the seals. Will need to repair with Eternabond tape in the near future and definitely by next year.
 Repair issues  N/A. Will do Eternabond at next maintenance.


 Inspect  Significant rust. Considering replacing when these become unserviceable.
 Lubricate  Sprayed liberally with silicone lubricant.


Paint  N/A. Did not paint steps.
 Lubricate hinges  Sprayed hinges with silicone lubricant.

Fresh Water

 Sanitize  Followed recommended procedure to drain, sanitized, flush, and refill the fresh water system. I may write a separate blog detailing that process.

Septic system

Clean tank Tank has been kept very clean over the last year so no action necessary.
Sanitize gear Gear was kept clean over the last year so no action was necessary.

Hot Water (Gas)

Test striker Lit and ran hot water heater on gas
Clean Cleaned using vacuum and compressed air

Refrigerator (Gas)

Test striker Lit and ran refrigerator on gas
Clean Cleaned using vacuum and compressed air

Stove (Gas)

Test striker Lit and ran stove on gas

Air Conditioner

Inpect and Clean filter Internal parts are starting to rust, but unit running well.


Clean Sprayed with LA’s Totally Awesome to kill mildew
Inspect Some rust on screw heads, etc.
Lubricate Sprayed liberally all joints and moving parts with silicone lubricant.


Inspect Inspected rubber, hubs, and suspension. No issues.
Grease hubs Dexter EZ-Lube hubs were easy to re-grease by following instructions on YouTube.

Leave a Reply

Your email address will not be published. Required fields are marked *